The London and Country Brewer | Page 5

as soon as it begins to come or spire, then turn it every three, four or five Hours, as was done before according to the temper of the Air, which greatly governs this management, and as it comes or works more, so must the Heap be spreaded and thinned larger to cool it. Thus it may lye and be work'd on the floor in several parallels, two or three Foot thick, ten or more Foot broad, and fourteen or more in length to Chip and Spire; but not too much nor too soft; and when it is come enough, it is to be turned twelve or sixteen times in twenty-four Hours, if the Season is warm, as in March, April or May; and when it is fixed and the Root begins to be dead, then it must be thickned again and carefully kept often turned and work'd, that the growing of the Root may not revive, and this is better done with the Shoes off than on; and here the Workman's Art and Diligence in particular is tryed in keeping the floor clear and turning the Malt often, that it neither moulds nor Aker-spires, that is, that the Blade does not grow out at the opposite end of the Root; for if it does, the flower and strength of the Malt is gone, and nothing left behind but the Aker-spire, Husk and Tail: Now when it is at this degree and fit for the Kiln, it is often practised to put it into a Heap and let it lye twelve Hours before it is turned, to heat and mellow, which will much improve the Malt if it is done with moderation, and after that time it must be turned every six Hours during twenty four; but if it is overheated, it will become like Grease and be spoiled, or at least cause the Drink to be unwholsome; when this Operation is over, it then must be put on the Kiln to dry four, six or twelve Hours, according to the nature of the Malt, for the pale sort requires more leisure and less fire than the amber or brown sorts: Three Inches thick was formerly thought a sufficient depth for the Malt to lye on the Hair-cloth, but now six is often allowed it to a fault; fourteen or sixteen Foot square will dry about two Quarters if the Malt lyes four Inches thick, and here it should be turned every two, three or four Hours keeping the Hair-cloth clear: The time of preparing it from the Cistern to the Kiln is uncertain; according to the Season of the Year; in moderate weather three Weeks is often sufficient. If the Exciseman takes his Gage on the floor he allows ten in the Score, but he sometimes Gages in Cistern, Couch, Floor and Kiln, and where he can make most, there he fixes his Charge: When the Malt is dryed, it must not cool on the Kiln, but be directly thrown off, not into a Heap, but spreaded wide in an airy place, till it is thoroughly cool, then put it into a Heap or otherwise dispose of it.
There are several methods used in drying of Malts, as the Iron Plate-frame, the Tyle-frame, that are both full of little Holes: The Brass-wyred and Iron-wyred Frame, and the Hair-cloth; the Iron and Tyled one, were chiefly Invented for drying of brown Malts and saving of Fuel, for these when they come to be thorough hot will make the Corns crack and jump by the fierceness of their heat, so that they will be roasted or scorch'd in a little time, and after they are off the Kiln, to plump the body of the Corn and make it take the Eye, some will sprinkle water over it that it may meet with the better Market. But if such Malt is not used quickly, it will slacken and lose its Spirits to a great degree, and perhaps in half a Year or less may be taken by the Whools and spoiled: Such hasty dryings or scorchings are also apt to bitter the Malt by burning its skin, and therefore these Kilns are not so much used now as formerly: The Wyre-frames indeed are something better, yet they are apt to scorch the outward part of the Corn, that cannot be got off so soon as the Hair-cloth admits of, for these must be swept, when the other is only turned at once; however these last three ways are now in much request for drying pale and amber Malts, because their fire may be kept with more leisure, and the Malt more gradually and truer dyed, but by many the Hair-cloth is reckoned the best of all.
Malts are dryed with several sorts of Fuel; as