The American Practical Brewer and Tanner | Page 9

than that malt which is only bruised or cracked, and for this simple reason, that all imperfect-made malt has a great proportion of its bulk unmalted, and, of course, in a crude hard state, which will partially dissolve in water if ground fine, but will not dissolve at all if only cracked or bruised. A further object of the brewer's attention should be to prevent the dispersion, or waste, of the finer parts of the malt, so apt to fly off in the grinding, if not prevented by having the malt bin close covered, as well as the spout leading into it from the stones; trifling as this precaution may seem, it is well worth the brewer's attention. Here it may not be improper to observe, that in all cases of horse, or cattle mills, where the shaft of the main wheel is perpendicular, no better ingredient can be placed in the chamber of the lower box than quick silver, which is far superior to oil or grease, and will not require renewing for a long time. The brass of a mill, managed in this way, might be expected to last twenty years, and the movement smoother and easier. This economical substitute for oil and grease can, with equal advantage, be applied to water mills, whether their shafts be horizontal or perpendicular; in a word, to all kinds of machinery, where the preservation of the gudgeons and brasses are an object.

Malting.
The production of good malt is, without question, the key-stone of the arch of brewing; therefore the brewer's attention should be invariably directed to this point, as the most difficult and important part of his operations. The process of making malt is an artificial or forced vegetation, in which, the nearer we approach nature in her ordinary progress, the more certainly shall we arrive at the perfection of which the subject is capable. The farmer prefers a dry season to sow his small grain, that the common moisture of the earth may but gently insinuate itself into the pores of the grain, and thence gradually dispose it for the reception of the future shower, and the action of vegetation. The maltster cannot proceed by such slow degrees, but makes an immersion in water a substitute for the moisture of the earth, where a few hours infusion is equal to many days employed in the ordinary course of vegetation, and the grain is accordingly removed as soon as it appears fully saturated, lest a solution, and, consequently, a destruction of some of its parts should be the effect of a longer continuance in water, instead of that separation, which is begun by the introduction of watery particles into the body. Were it to be spread thin after this removal, it would become dry, and no vegetation would ensue; but being thrown into the couch, a kind of vegetative fermentation commences, which generates heat, and produces the first appearance of a vegetation. This state of the barley is nearly the same with that of many days continuance in the earth after sowing, but being in so large a body, it requires occasionally to be turned over and spread thinner; the former, to give the outward parts of the heap their share of the acquired warmth and moisture, both of which are lessened by exposure to the air; the latter, to prevent the progress of the vegetative to the putrefactive fermentation, which would be the consequence of suffering it to proceed beyond a certain degree. To supply the moisture thus continually decreasing by evaporation and consumption, an occasional, but sparing, sprinkling of water should be given to the floor, to recruit the languishing powers of vegetation, and imitate the shower upon the cornfield; but this should not be too often repeated; for, as in the field, too much rain, and too little sun, produces rank stems and thin ears, so here would too much water, and, of course, too little dry warmth, accelerate the growth of the malt, so as to occasion the extraction and loss of such of its valuable parts as, by a slower process, would have been duly separated and left behind. By the slow mode of conducting vegetation here recommended, an actual and minute separation of the parts takes place; the germination of the radicles and acrospire carries off the cohesive properties of the barley, thereby contributing to the preparation of the saccharine matter, which it has no tendency to extract, or otherwise injure, but to increase and meliorate, so long as the acrospire is confined within the husk; and by as much as it is wanting of the end of the grain, by so much does the malt fall short of perfection; and in proportion as it is advanced beyond, is that purpose defeated.
This is very evident to